Home  >  Farm Machinery  >  Farm Machinery  >  Silos

1.Thermal silo, 2. Keep the grain in a good quality, 3. Insulation silo can make low temperature - details see: https://www.machineto.com/thermal-insulation-silo-for-storing-grain-10191145

Thermal Insulation Silo for Storing Grain for Sale

Specification:

Model: TCZK10012

Volume: 1271stere

Capacity: 1000t(calculate by density of 0.78t/m3)

Diameter: 10.089m

Layer : 12

Hopper Cone Angle : 45degree

Ring Beam Height : 5.890m

Eave height : 19.385m

Total Height : 21.720m

Coating: Galvanized 275/350/400g/m2

Usage: Insulating, storing Grain(Rice/Soybean/Soya/Walnut) which can keep the material in a good quality

Installation of Insulation Silo

Different from general silo, insulation silo can keep a low temperature, which can keep the material in a good quality,

There are three layers in the wall, separately they are: galvanized steel sheet (inside); insulation rock wool (middle); color steel (outside), this can put insulating into practice.

Another hand,in the tropical zone, we will add a refrigerator under the bottom, blow the cold air into the silo.

The insulation silo can be used as cold-proof, winter protection, and widely used in tropical countries, to reduce temperature in silo, such as Myanmar, Vietnam, Cambodia, New Zealand and Australia .etc.

Before now, TSE has both these two projects engineering.

Features of insulation silo

• 1.Thermal insulation
• Grain temperature change gradient inside silos is lower than that outside,thus not likely to have condensation of moisture.
• 2.Safe grain storage
• Storing in a low temperature,increase the grain storage stability,keeps the grain quality and prolongs the safe-storage period
• 3.Low fabrication cost
• With installing an insulation layer(Polyurethane froth,rubber single,glass fiber etc.) on the outer wall,insulation silo can have a low fabrication cost compared to concrete silo.

Silo Capacity Range and Specification

Silo type	Hopper bottom silo		Flat bottom silo
Bottom Cone Degree	45 degree	55 degree
Diameter	1.8m-11m	1.8m-7.334m	3.6m-32.1m
Capacity	5.4t-1428t	5.8t-755t	30t-20068t
Volume	7.2m3-1855m3	8.4m3-981m3	39m3-26000m3
Accessory Equipments:
- Bucket Elevator with capacity from 1 tone/hour to 400 tone/hour - Chain Conveyor with capacity from 1 tone/hour to 400 tone/hour - Screw Conveyor with capacity from 1 tone/hour to 200 tone/hour - Elevator Towers - Electrical and Manuel controlled Slide gates - Distributors with 1 in 2/3/4/5/6 out - Catwalks - Spout Pipes
Machines:
- Drying Machines ( Tower Type and Horizontal Type ) with capacity from 5 tone/hour to 50 tone/hour - Mill Machines with capacity from 5 tone/hour to 50 tone/hour - Pellet Machines with capacity from 5 tone/hour to 50 tone/hour --Level sensors, aeration system with centrifugal fan, temperature control system and sweep auger, dedusting system as an option.

Insulation Silo Project in Myanmar, 2010:

This is our previous project of insulation silo in Myanmar, 2010. 10sets*1000t rice. Hopper bottom silo

The insulation coating is 100 percent, including the silo roof, silo body and hopper bottom.

It could prolong the life of grain and keeps grain in a good quality since the changes of ambient temperature will not influence the temperature inside silos.

Insulations are widely used in tropical area.

Special requirement(LARGE CAPACITY)

Sometime, client want large capacity silo which is hopper bottom silo, but steel leg hopper bottom silo can support a range of 10t to 1500 tons,

Generally, the method is adopting cement bottom silo which can support weight range from 1500tons to 15000tons.

Cost of it is higher than general one, but advantage of hopper bottom silo can put natural flow into practice.

the second advantage is that save power (flat bottom silo should use a sweep auger to run out the grain),

Below is a group of cement bottom insulation silo we've done before.

Installation

Client and our saleman

Shipment

TSE brief introduction

Tai'an Shelley Engineering Co.,ltd. is a professional supplier of Grain silo system.
TSE now is having branch office in China and Bangladesh, Mongolia etc

TSE activities cover research & development, project design, manufacturing, installation and services in a multitude of industries including storage engineering, environmental protection, conveying equipment and elevating systems.

TSE provides assembly steel silos with bin capacity of 10—15000tons in such different discharge forms as flat bottom, cone bottom, fluidized discharging,muti-outlet discharging etc.., and undertake turnkey project starting from process and civil work design, auto-control system as well as manufacture,installation,commissioning of the associated equipment for lifting,cleaning,magnetic
separating,metering,drying,fumigating,cold storing,ventiationg,dust collecting,temperature and moisture measuring etc. up to personal training and so on.
The grain silo system from TSE is made according to Chinese National Standard,If customers have request,TSE can also supply the International Standard grain silo system;

We have passed ISO9001, CE, and BV certification.

Welcome to your enquiry, edit by Fred Liang